MICCROSHIELD STOP-OFF LACQUER (1 Gallon Can)

Purchase MICCROSHIELD STOP-OFF LACQUER (1 Gallon Can)

MICCROSHIELD STOP-OFF LACQUER (1 Gallon Can)

MICCROSHIELD is a high-solids, air-dry lacquer, transparent orange/red in color, that can be applied by brushing, dipping or spraying if diluted properly.

MICCROSHIELD is suitable for masking in the following cycles:
Electropolishing;  Electroless Nickel;  Neutral and Acid Gold Palladium;  Indium Rhodium;  Anodizing Bronze; Any Acid Cycle Silver; Chrome.

APPLICATION PROCEDURE

1. Chemically and/or mechanically clean the area of the part to be masked. The area to be masked must be free of all dirt, grease, oil or other contaminants. Cleaning is the most critical aspect of the masking process.

Apply MICCROSHIELD to the area to be masked by dipping, brushing, or spraying.  Appropriate dilution of MICCROSHIELD is required for spraying. For reducing MICCROSHIELD use MICCROSHIELD REDUCER only!

Apply a minimum of 2 successive coats of MICCROSHIELD to the area to be masked, allowing a minimum of 30 minutes air-dry time between coats and overnight air-dry time after final coat before introduction into solution. Faster drying of MICCROSHIELD can be accomplished by force-drying for 15 minutes in an oven not exceeding 140_ F, or over a hot plate not exceeding 140_ F. Drying time will vary depending on relative humidity. Make sure MICCROSHIELD has lost all solvent odor before force drying or applying additional coats. Drying over a hot plate is preferable to oven drying.

4. For extra long cycles, 3 coats are recommended. If area to be masked is highly polished, see back page for additional application procedures.

5. MICCROSHIELD can be removed using MICCROSTRIP B or MICCROSTRIP A.  MICCROSHIELD REDUCER is also effective but somewhat slower.

6. Replace evaporated solvent with MICCROSHIELD REDUCER ONLY!

COLOR: Transparent Orange/Red  

CHARACTERISTICS

WT./GAL.: 7.9#
VISCOSITY: 45-50 sec. #2 Zahn FLASH POINT: 30_ F, T.C.C.
COVERAGE RATE: Approx. 510 ft2 (47.4m2) per gallon, 1.1 mil dry film
MICCROSHIELD is available in: 1 gal., 5 gal., and 55 gal. containers.

PRECAUTIONARY INFORMATION

CONTAINS VOLATILE SOLVENTS_Keep away from sparks and open flame. Keep container closed when not in use. Store at temperatures above 32_F and below 1 05_F. Maintain adequate ventilation in working area. Wear approved respirators and protective clothing when working in confined areas. Avoid repeated breating of concentrated vapors. Prolonged contact of liquid material with the skin may be irritating. In case of skin contact, wash exposed skin surface thoroughly with soap and water. In case of eye contact, flush eyes thoroughly with water for 15 minutes and consult a physician. Refer to MATERIAL SAFETY DATA SHEET for further infommation.

Purchase MICCROSHIELD STOP-OFF LACQUER (1 Gallon Can)

  • Gallade Part#: MS5901
  • Mfr Part#: MS5901
  • Brand: Tolber
  • Container: 1 Gallon Can
  • Misc: Can

    Other products in the category Chemicals for Special Applications / Plating:

    MICCRO SH-110 VOC FREE  1 Gal Can MICCRO SH-110 VOC FREE 1 Gal Can

    MICCRO SUPER XP-2000 STOP-OFF LACQUER 1 Gal Can MICCRO SUPER XP-2000 STOP-OFF LACQUER 1 Gal Can

    MICCRO SUPER XP-2000 STOP-OFF LACQUER 5 Gal Can MICCRO SUPER XP-2000 STOP-OFF LACQUER 5 Gal Can

    MICCROMASK REDUCER  1 Gal Can MICCROMASK REDUCER 1 Gal Can

    MICCROMASK STOP-OFF LACQUER  1 Gal Can MICCROMASK STOP-OFF LACQUER 1 Gal Can

    MICCROMASK STOP-OFF LACQUER  5 Gal Can MICCROMASK STOP-OFF LACQUER 5 Gal Can

    MICCROPATCH MC-753 AIR DRY PATCH FOR PLASTISOL COATINGS BLACK  1 Gal Can MICCROPATCH MC-753 AIR DRY PATCH FOR PLASTISOL COATINGS BLACK 1 Gal Can

    MICCROPATCH MC-753 AIR DRY PATCH FOR PLASTISOL COATINGS BLACK  5 Gal Can MICCROPATCH MC-753 AIR DRY PATCH FOR PLASTISOL COATINGS BLACK 5 Gal Can

    MICCROPEEL LACQUER  1 Gal Can MICCROPEEL LACQUER 1 Gal Can

    MICCROSHIELD STOP-OFF LACQUER 5 Gal Can MICCROSHIELD STOP-OFF LACQUER 5 Gal Can

    MICCROSHIELD STOP-PEEL REDUCER  1 Gal Can MICCROSHIELD STOP-PEEL REDUCER 1 Gal Can

    MICCROSHIELD STOP-PEEL REDUCER  5 Gal Can MICCROSHIELD STOP-PEEL REDUCER 5 Gal Can

    MICCROSTOP STOP-OFF LACQUER   5 Gal Can MICCROSTOP STOP-OFF LACQUER 5 Gal Can

    MICCROSTOP STOP-OFF LACQUER  (1 Gal Can) M59012 Tolber MICCROSTOP STOP-OFF LACQUER (1 Gal Can) M59012 Tolber

    MICCROSTRIP  "A"    1 Gal Can MICCROSTRIP "A" 1 Gal Can

    MICCROSTRIP  "A"    5 Gal Can MICCROSTRIP "A" 5 Gal Can

    MICCROTAPE # 1210, 1in    1 Each Roll MICCROTAPE # 1210, 1in 1 Each Roll

    MICCROTAPE 3/4" BLACK  1 Each Roll HAZMAT MICCROTAPE 3/4" BLACK 1 Each Roll HAZMAT

    MICCROTAPE CEMENT      1 Gal Can MICCROTAPE CEMENT 1 Gal Can

    MICCROTEX LACQUER       1 Gal Can MICCROTEX LACQUER 1 Gal Can

    MICCROTEX/MICCROPATCH REDUCER  1 Gal Can MICCROTEX/MICCROPATCH REDUCER 1 Gal Can

    MICRO XP-2000 LR LACQUER  1 Gal Can MICRO XP-2000 LR LACQUER 1 Gal Can

    PLASTISOL BLACK  1 Gal Can PLASTISOL BLACK 1 Gal Can -- Product Specs

    PLASTISOL BLACK  5 Gal Can PLASTISOL BLACK 5 Gal Can -- Product Specs

    PLASTISOL ORANGE  1 Gal Can PLASTISOL ORANGE 1 Gal Can -- Product Specs

    PLASTISOL ORANGE  5 Gal Can PLASTISOL ORANGE 5 Gal Can -- Product Specs

    SUPER XP-2000 REDUCER  1 Gal Can SUPER XP-2000 REDUCER 1 Gal Can

    T-100 PLASTISOL PRIMER  1 Gal Can T-100 PLASTISOL PRIMER 1 Gal Can

    T-100 PLASTISOL PRIMER  5 Gal Can T-100 PLASTISOL PRIMER 5 Gal Can

    T-100 PLASTISOL PRIMER REDUCER  1 Gal Can T-100 PLASTISOL PRIMER REDUCER 1 Gal Can

    T-100 PLASTISOL PRIMER REDUCER  5 Gal Can T-100 PLASTISOL PRIMER REDUCER 5 Gal Can

    XP-420 LVOC L.R.   5 Gal Can XP-420 LVOC L.R. 5 Gal Can



    Store Home | Chemicals A-Z | Chemicals for Special Applications | Brands



    Google
     




    Gallade Chemical
    Gallade Chemical shopping cart powered by Nexternal
  •